Mighty East Penn Battery Catalog 2019

REFERENCE NOTES 399

Batteries are Recyclable! Imagine the environmental damage that can be have a higher recycling rate than other waste products caused by carelessly discarding 18 pounds of lead, such as aluminum, paper, and beverage containers two pounds of plastic, and a gallon of acid: the contents of a lead-acid battery. made of glass or plastic, just to name a few. Over Now imagine that damage compounded 98% of all used batteries are recycled today. by 75,000,000: the approximate number This is an EPA-permitted recycling of lead-acid batteries available for recy- system, which is important for you to know cling each year in the United States. because hazardous disposal laws place heavy penalties on offenders and consider- Fortunately, scrap lead-acid batteries able paperwork burden on everyone. You can can be safely recycled. In fact, they have been recycled since the 1920s, and today these batteries be assured that your scrap is being recycled in an environmentally safe manner. Scrap lead-acid batteries are disassembled in a ventilated battery breaker, where the lead, plastic and acid are safely separated. REFERENCE The recycled plastic from the bat- The lead is processed and smelted in the tery cases and covers is reclaimed reverberatory furnace, producing metal which in the plastic recovery plant, where goes to the refinery. There it is placed in kettles, it is cleaned and separated into combined with reagents, and alloyed into lead polypropylene and lead-bearing for use in new batteries. materials. Polypropylene is recycled to make cases and covers for new Battery acid is recycled batteries and other plastic products. in a patented acid reclamation plant. This 400 one-of-a-kind, computer- controlled facility allows recycling of used battery acid for use in the produc- tion of new batteries. Tests show no difference in the performance of bat- teries using recycled sulfu- ric acid when compared to batteries using new acid.

FOOTNOTES 1 Battery gasses need to be vented to outside. 160 Some may require spl. 8-volt battery. 2 Check terminal post arrangement carefully! Could be top or side terminals. 161 Watch polarity 3 Deep cycle battery required. Watch polarity! 162 Group 31 O.E. battery has non-standard SAE terminal locations and 5 Hood or cover clearance may not be sufficient. Check polarity to avoid may require cable modifications. explosion. 163 Direct electric start 6 Installation may take over 30 mins. 164 Gas starting engine 8 Best Performance Estimate 165 12-Volt 10 Need flush cover battery to fit under shield or to clear. May need to remove 166 24-Volt 167 Could be 12 or 24 Volt System. Assure correct battery voltage height adjuster. 11 Battery is encased within an Active Cooling Box with an air snorkel to the BEFORE installation! 168 Air start outside of the engine compartment 169 Military 6TL 12 Non-BCI group size. 170 Special 12-volt battery 15 Two batteries required. For best results, replace both of same type. 171 Electric start 16 Vibration proof battery. Replacement not available. 172 6-Volt 17 Watch polarity and clearance! Vehicle could have reverse terminal battery. 173 Requires 4 batteries 18 Gr. 31 battery w/ SAE terminal posts. 174 Requires 4 or 8 batteries 21 OE battery has special terminals. Cable change is necessary. 175 Requires 1 to 5 batteries 22 Reverse terminal battery required. May need to change cable. Watch polarity! 177 Requires 1, 2 or 3 batteries 24 OEM Used various size batteries in production. Check original battery for 178 Requires 6 batteries 179 Requires 1 to 4 batteries size and correct fit. 181 Requires 3 batteries 25 Replacement battery is taller than OE. Check height clearance before closing 183 Special European size required 184 Battery located behind passenger seat. hood or cover. 193 The listed 6-volt sizes were used during these years: ( 26 Replacement battery is wider than OE. Hold-down and/or tray replacement Check dimensions, clearance, & polarity carefully!) may be necessary. 204 Sensor modifications may be necessary. 27 Check OE CCA requirements. Replacement CCA may not be sufficient. 208 Battery located under floor on passenger side. 28 Replacement battery is longer and taller than OE. Check height clearance 213 OE does not require AGM battery. 215 Spacer may be required. carefully. Hold-down and/or tray replacement may be necessary. 218 Refer to owner's manual for electrical set up requirements. 29 Battery hold-down may need to be replaced and/or modified. Battery cable 231 Battery Located Under Drivers Footwell. 235 w/sensor replacement may be necessary. 243 Battery shield may need to be modified. Do Not Remove. 30 Replacement battery is wider and taller than OE. Hold-down and/or tray 244 Replacement battery is longer than OE. Hold-down, heat shield and/or tray replacement may be necessary. replacement may be necessary. 31 Replacement battery is longer and wider than OE. Hold-down and/or tray 247 DIN/EN size 249 Battery located between left front headlight assembly & left front wheel replacement may be necessary. 32 Replacement battery is longer than OE. Hold-down and/or tray replacement splash shield. 250 Battery located in cargo area. may be necessary. 251 Battery located in compartment behind left front fender. 33 Height adapter may be required on Dual Terminal batteries. 252 Battery located in floor pan in 2nd row passenger area. 34 OE Battery Has Flush Vents. 253 Battery located in front trunk. 35 Battery w/ handle brackets will not fit. 254 Battery located in luggage compartment. 37 Best fit estimate, Mfr. Recommended replacement battery shown, may vary 255 Battery located in passenger side frame rail, behind the front passenger door. 256 Battery located under passenger front seat. from OE battery. Check clearance before connecting cables. 257 Battery located under passenger rear seat. 39 Could be 6 or 12 Volt System. Assure correct battery voltage 258 Battery located under passenger seat. 260 Vent tube may need to be modified for proper venting. BEFORE installation! 261 Battery located in engine compartment. 40 Battery located in wheel well - Remove front tire to access the battery. 262 Battery located in passenger footwell. 41 Battery located under the rear seat. 263 Battery located in passenger side front wheel well. 42 Battery located under hood, under the washer bottle. 264 Battery located in rear passenger footwell. 43 Battery located under hood, under the fuse box. 265 Battery located behind the left front fender and is accessible through the 44 Battery located under hood, under the fuse box. Power steering reservoir wheel well. must be moved. 266 Battery located behind the passenger seat in the floor. 45 Battery located under hood, under the air filter. 276 Call service specialist before changing battery 46 Battery located in trunk. Spare tire may have to be removed. 277 See manufacturer's service information for retrofit 47 OE battery is AGM 280 Battery located left hand side of luggage compartment. 49 Match to original battery to assure proper fit and polarity. 281 OE battery is EFB, Enhanced Flooded Battery. 50 Vehicle computer system must be reset and battery registered using scan 282 Li-ion Battery Only 286 Battery gasses need to be vented to outside. For proper venting instructions tool 52 Can be used as a possible alternative to OE battery with flag to post terminal see the last page of the reference section. 302 Battery located behind the passenger seat in the floor. adapter. 303 Battery located passenger side frame rail. 56 Hold-down modifications may be necessary. 306 Battery located Co-Drivers Legroom. 57 When ordering battery, specify sensor. 320 Requires 8 batteries 58 Battery must be rotated for correct polarity. Hold-down modifications may 321 Requires 12 batteries 322 Battery located in engine compartment, against firewall. be necessary. 323 Replacement battery is taller than OE. Check height clearance carefully. 64 Top and front terminal mounts only. 80 AGM Valve-Regulated Battery Required. Hold-down and/or tray replacement may be necessary. 133 Requires Special Steel Tray Industrial Battery Type 326 Battery located under the cabin air filter housing in engine compartment. 134 Starting or Deep Cycle Battery 328 Battery located in engine compartment, with fuseblock on top of battery. 135 Requires Gel Electrolyte 139 Battery Located in Trunk. 144 OE has replaced Gr. 76 with Gr. 79 145 OE Exact Fit 147 Two batteries may be required. 148 Two or more batteries required. For best results, replace all. 149 Amp hour rating from OE mfr is converted to approx. CCA rating (Ah x 10=approx. CCA) 150 Application may use 4D/800 151 Mfr. Recommended replacement battery shown, may vary from OE battery. 152 Battery Located in Left Rear Tire Well. Remove Tire. 153 Battery Located Under Drivers Seat. 155 Requires special 6-volt assembly. 156 The rating shown is based upon battery industry consensus. 158 Group 34 or 78

Catalog No. BAT-19 Supercedes BAT-16 Issued February 2019 DISTRIBUTED BY *BAT-19* BAT-19 © 2019 MIGHTY DISTRIBUTING SYSTEM OF AMERICA • NORCROSS GA 30092 www.mightyautoparts.com