s60

Section 6 • Schematics Electrical Schematic, S-60 / S-65 / S60 TRAX / S65 TRAX BATGND 6 D23 3 4 TB30 5 6 23 8 6 - 243 Perkins Engine Models (AS) (after SN 21629) C41RPM OR/BK 5 C159STC BL/WH 4 C160JPL WH/RD C7P-3 BATGND C7B-3 7 GROUND Perkins 404-22 Engine 1 JC3 3 C159STC BL/WH I HG F E DCB A BR C4P-4 SNSR-GND OR/RD C4B-4 C6-33 C123PBS RD/BK 1 2 3 4 56 YL S18 ROCKER / STEER OPTION 2 P162JPW OR 2 GR/WH C4P-9 P109ANG OR/WH C4B-9 C6-34 SNSR-GND BR BR PRIMARY BOOM ANGLE C28TTA RD/BK C6-20 P109ANG GR/WH OR SENSOR - SAFETY P26ESTP BK 1 BR C123PBS GR/RD C4B-8 BL C41RPM OR/BK C2B-3 S17 C30FWD WH C1B-4 BK PRIMARY BOOM ANGLE C31REV WH/BK C1B-5 SENSOR - OPERATIONAL RD J114 2 RD/BK C4P-8 5 C2P-3 9 J1 J1 J2 J2 15 C1P-4 C5-21 C30FWD WH 14 BK RDY3 Y27 U4 EDC - DRIVE FORWARD 10 16 C1P-5 C5-20 C31REV WH/BK RD BK EDC - DRIVE REVERSE 15 TB31 H3 S-60 • S-65 • S-60 TRAX • S-65 TRAX S-60 HC • S-60X •S-60XC TS14 DRIVE MODE C6-32 C130TA WH/RD TRAVEL ALARM C29MS RD/WH C5-23 C32BRK WH/RD C26-1 (OPTION) 8 C1P-6 C32BRK WH/RD C1B-6 C26-2 CDE3 BL/RD 16 19 BRAKE RELEASE TB29 TB32 Y2 20 C1P-3 2 SPEED TS15 L1 C29MS RD/WH C1B03 C5-24 C29MS RD/WH C28-1 C28-2 MOTOR STROKE 18 C1P-11 CDE1 BL/WH 7 17 C1P-10 C37SCW BL/BK C1B-11 C6-37 C37SCW BL/BK C25-1 C25-2 STEER CW 11 C3P-6 C6-36 C36SCC BL C24-1 C24-2 STEER CCW RIGHT DRIVE ENABLE 10 C3P-4 C36SCC BL C1B-10 LEFT 9 C3P-5 CDE2 BL/BK 6 Y23 Y4 C6TRF WH/RD C3B-6 C4TRL WH C3B-4 C6-4 C4TRL WH C14-1 C14-2 TURNTABLE ROTATE C6-5 C5TRR WH/BK C15-1 C15-2 CW 4 C5TRR WH/BK C3B-5 TB7 5 TB8 TB4 TURNTABLE ROTATE 13 TB5 Y24 CCW 14 U13 J1 RIGHT TURNTABLE ROTATE ALC-500 JOYSTICK LEFT TS62 LEFT R2 R2 5W 7.5W C6-6 C6TRF WH/RD C31-1 C31-2 TURNTABLE ROTATE CR19 FLOW CONTROL Y26 Y13 J25 14 C3P-9 C9PER BK/RD C3B-9 13 C3P-8 C8PBR BK/WH C3B-8 P24FS WH CONTROL CARD J2 12 C3P-7 C7PBE BK C3B-7 C6-7 C37-1 RD C16-1 C16-2 LSB2S RD NC 21 C37-2 LOOSE CABLE LIMIT SWITCH 22 BR PRIMARY BOOM EXTEND EXTEND Y25 PRIMARY BOOM PRIMARY BOOM TS63 C6-8 C8PBR BK/WH C17-1 C17-2 RETRACT RETRACT C6-9 C9PER BK/RD C30-1 C30-2 PRIMARY BOOM EXTEND / RETRACT December 2013 TB9 FLOW CONTROL Part No.147753 Y15 1J8 5 P134 RD C6-25 BL 4 321 RD LST3O - ZONE A 22 21 10 NC BR GROUND BOX 8 BK SPEED REDUCTION 14 13 7 WH OPERATIONAL LIMIT SWITCH NO 6 TB1 Y22 2 TB3 C6-1 C1PBU RD C12-1 C12-2 PRIMARY BOOM 3 C6-2 UP C163PLS WH/BK 2 J1 UP C6-3 C2PBD RD/BK C13-1 C13-2 C165TRS WH/RD 1 PRIMARY BOOM PRIMARY BOOM C164PES RD/WH 11 C6-29 DOWN P162JPW OR 12 DOWN BR PRIMARY BOOM P26 ESTP R16 C3PBF RD/WH C29-1 Y12 Y21 C29-2 UP / DOWN 5W FLOW CONTROL J127 TS61 CR34 C118LS OR R14 CR34 - SPEED REDUCTION 6 10W RELAY 5 4 3 2 1 JC7 OR 6 C3P-1 C1PBU RD C3B-1 TB2 7 C3P-2 8 C3P-3 C2PBD RD/BK C3B-2 BR 1 3 C4P-1 C3PBF RD/WH C3B-3 P24FS WH 2 4 C2P-2 P24 4 J3 D27 J2 C8 RD 22 21 LST1O P26EST WH 3 C2P-4 21 BR NC DRIVE ENABLE 1 C13DE BL/RD C4B-1 BL/RD C6-13 P22LS BK BK LIMIT SWITCH C13DRE BL/RD WH 14 13 NO LST2O - STOWED ANGLE C40LS OR RD DRIVE SPEED REDUCTION D24 C42LS OR/RD C10 BR 22 21 LIMIT SWITCH P22LS BK 21 BK NC C40LS OR C2B-2 C6-40 WH LSB1RO - BOOM RETRACT C6-31 C6-11 BL/BK 14 13 DRIVE / ROTATE SPEED C37-3 BK RD NO LIMIT SWITCH BR KJ CR27 CR30 LIFT / DRIVE C42LS OR/RD C2B-4 OR/RD C11 BK 22 21 L46 / L47 NC NO (OPTION) C6-22 21 WH NC LOOSE CABLE LED TB22 WH C37-4 14 13 LSB2S TB59 NO LOOSE CABLE LIMIT SWITCH P22LS BK L46 Downloaded from www.Manualslib.com manuals search engine C3P-11 C59CNK BL/BK C3B-11 TS9 P134 RD C6-24 13 L47 TB134 BK C4B-2 NO DOWN PLATFORM C4P-2 C14PLU OR C4B-3 UP LEVEL C4P-3 C15PLD OR/BK 14 Y17 Y16 Y19 Y20 TS59 TB14 C6-14 C14PLU OR C20-1 C20-2 PLATFORM LEVEL UP C6-15 C15PLD OR/BK C21-1 C21-2 PLATFORM LEVEL DOWN BR UP PLAT. LEVEL WH DOWN TS8 JIB BOOM TB44 TB15 (S-65 OPTION) C3P-10 C129JDA BL C3B-10 C4P-6 C18JD/PRR GR/BK C4B-6 C4P-5 C4B-5 DOWN C17JU/PRL GR D28 UP TB18 NM L CR13 TS58 DOWN JIB BOOM C6-18 C18JD/PRR GR/BK C23-1 C23-2 PLATFORM ROTATE RIGHT NC UP (S-65 OPTION) C6-17 C17JU/PRL GR C22-1 C22-2 (JIB BOOM DOWN / S-65 OPTION) TS7 PLATFORM TB17 PLATFORM ROTATE LEFT ROTATE D29 (JIB BOOM UP / S-65 OPTION) CW CW PLAT. ROTATE CCW CCW TS57 C4P-7 C6-19 C129 RD/BK DESCENT ALRM TB19 H4 D30 C19JSV GR/WH C4B-7 RD C1 - JIB VALVE + C41RPM OR/BK P22LS BK RD (AUX & FE) BR P134 RD RD (AUX) C28TTA RD/BK P26ESTP BK P24FS WH Y11 CR14 NO

December 2013 Section 6 • Schematics Electrical Schematic, S-60 / S-65 / S60 TRAX / S65 TRAX Perkins Engine Models (AS) (after SN 21629) 6 - 243 6 - 244 Downloaded from www.Manualslib.com manuals search engine

Section 6 • Schematics December 2013 Ground Control Box Terminal Strip Wiring Diagram S-60/S-65/S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) 6 - 245 6 - 246 Downloaded from www.Manualslib.com manuals search engine

Downloaded from www.Manualslib.com manuals search engine 6 - 246 8 AUX 7 BK BRN 5 BK/RD-35C 4 C21IGN WH 3 2 4 BK-22D 1 Ground Control Box Terminal Strip Wiring Diagram S-60/S-65 Section 6 • Schematics S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) Perkins 404-22 Engine CR1 6 CR2 RD CR45 RD BRN BK-ISM1 CR4 OR/RD RD CB3-2 U33 AB WH U34-8 BRN RD-24B BRN C32 C21IGN WH C5-11 CB7 WH-21B (1) CB7 BK/RD 12 BRN GND BRN P48PWR WH C45-87 S-60 • S-65 • S-60 TRAX • S-65 TRAX BAT BRN BK C5-5 8 GR/BK H6 7 RD-TS52 6 RD-TS51 5 BK C7B-1 3 BL/WH-C1B-12 1 RD H6 S-60 HC • S-60X • S-60XC BRN BK/RD-CR4 BK/RD C5 P20BAT RD C5-18 C32 P20BAT RD RD - TB134-3D C6 WH - ISM#9 C5-7 WH - CR2 BK C6-10 WH/RD-6D RD-27C BRN RD/WH-3D C4B 35GR/RD C4B-102 U34 BRN BK-22C1 CR19 CR34 WH C5-4 (BROWN) BR - GND GR C2B-5 OR C5-1 C3B 9 8 C21IGN WH (GREEN) C2B CR5 C6 C5 C132PLI2 BL/WH C1B-12 P134PWR RD-134-2D C (BLACK)GR/BK-L45 RD-TS61 RD-ISM4 CR17 C1B RD/BK-ALARM RD/BK-TS61 WH/RD-R2 (GREY) RD/WH-CR34 WH/RD-R4 WH-TS62 WH/BK-TS62 RD/WH-R16 OR C38-2 WH/RD-CR19 RD/WH-TS61 BK-TS63 BK/WH-TS63 RD-CB3 + BK/RD-TS63 OR-TS59 C6-19 H6 OR/BK-TS59 GR-TS57 DC TERMINAL BASE (TB) B A C1PBU RD C3B-1 GR/BK-TS57 GR/WH-TS57 1 PRIMARY BOOM UP 1 C1PBU RD C6-1 RD-CB2 C2PBD RD/BK C3B-2 RD-CB1 D29 2 PRIMARY BOOM DOWN 2 C2PBD RD/BK C6-2 DE F C3PBF RD/WH C3B-3 BK RD 3 PRIMARY BOOM UP/DOWN FUNC CTRL 3 C3PBF RD/WH C6-3 WH C4TRL WH C3B-4 4 TURNTABLE ROTATE LEFT 4 C4TRL WH C6-4 C5TRR WH/BK C3B-5 5 TURNTABLE ROTATE RIGHT 5 C5TRR WH/BK C6-5 OPT C6TRF WH/RD C3B-6 6 TURNTABLE ROTATE FUNC CONTROL 6 C6TRF WH/RD C6-6 C7PBE BK C3B-7 7 PRIMARY BOOM EXTEND 7 C7PBE BK-LS5 C6-7 C8PBR BK/WH C3B-8 8 PRIMARY BOOM RETRACT 8 C8PBR BK/WH C6-8 C9PER BK/RD C3B-9 Part No.147753 9 PRIMARY BOOM EXT/RET FUNC. CTRL 9 C9PER BK/RD C6-9 C133PLA GR/BK C3B-12 December 2013 C14PLU OR C4B-2 14 PLATFORM LEVEL UP 14 C14PLU OR C6-14 C15PLD OR/BK C4B-3 15 PLATFORM LEVEL DOWN 15 C15PLD OR/BK C6-15 C17JU GR C4B-5 17 PLATFORM ROTATE LEFT/JIB UP 17 C17JU GR C6-17 C18JD GR/BK C4B-6 18 PLATFORM ROTATE RIGHT/JIB DOWN 18 C18JD GR/BK C6-18 BATTERY POWER C19JSV GR/WH C4B-7 12V DC 19 JIB SELECT VALVE (S-65 OPTION) 19 P20BAT RD 20 +12 VOLT POWER (1) 20 P20BAT RD BRN-<GND> D52 20 +12 VOLT POWER (2) 20 C21IGN WH CR2 21 IGNITION POWER (1) 21 C21IGN2 WH C5-3 WH-HM 21 IGNITION POWER (2) 21 WH TB21 C4 BK-CR5 22 +12 VOLT TO PLATFORM (1) 22 C3 BK-KS1-1 22 +12 VOLT TO PLATFORM (2) 22 P22BAT BK C6-22 C5 BK C32-4 C6 G WH-ISM7 23 KEYSWITCH POWER (1) 23 P23BAT WH C7B-2 WH-KS1-3 WH U34-2 RD-ISM6 23 KEYSWITCH POWER (2) 23 RD-CR2 RD-CB1 WH-ISM10 24 CIRCUIT BREAKER POWER 24 C25PS WH/BK C5-16 CABLE #1 WH/RD-L2- 18/22 RD-CR19#86 25 OIL PRESSURE SWITCH 25 C26TS WH/RD C5-14 RD-TS51 C27AUX RD C1B-1 26 OIL TEMPERATURE SWITCH 26 C27AUX RD C6-27 WH/RD-C6-32 C29MS RD/WH C1B-3 BK-ISM3 27 AUXILARY PUMP 27 C29MS RD/WH C5-24 H BK-TS52 C30FWD WH C1B-4 RD/WH-TS61 BK/WH-TS56 29 MOTOR STROKE 29 C30FWD WH C5-21 CABLE #2 RD/WH-R16 BK/RD-CR4 C31REV WH/BK C1B-5 18/19 WH/RD-R4 30 PROPEL FORWARD 30 C31REV WH/BK C5-20 WH/RD-R2 OR/BK-ISM2 C32BRK WH/RD C1B-6 HARNESS TO BRN-GND 31 PROPEL REVERSE 31 C32BRK WH/RD C5-23 C1B-2 C28TTA RD/B C6-28 SWITCH PANEL BK BL-TS58 C33STR BK C1B-7 C1B-10 C36SCC BL C6-36 RD BL/BK-L46+ C34SA BK/WH C1B-8 RD-H6+ C34SA BK/WH C5-22 C2B-4 C42LS OR/RD C6-31 WH P134FB WH-C6-23 C35RPM BK/RD C1B-9 RD-KS C1B-11 C37SCW BL/BK C6-37 32 BRAKE 32 C39LP BL/RD C2B-1 C4 33 START ENGINE 33 C40LS1 OR C2B-2 C7 C40LS1 OR C6-40 C2 34 GLOW PLUG 34 C41RPM OR/BK C2B-3 C3 IJ C41RPM OR/BK C5-2 C5 35 HIGH FUNCTION SPEED 35 C129JDA BL C3B-10 C1 FUNCTION RD/BK-ALARM C6-19 C6 HARNESS 39 (UNUSED) 39 C45GEN GR/WH C5-12 C45GEN GR/WH C2B-7 C6 40 BOOM STOWED 40 C59CNK BL/BK C3B-11 C59CNK BL/BK C6-11 41 ALTERNATOR PULS PICKUP 41 P134PWR RD C2B-6 P134FB RD C6-23 NOTE: DASHED LINES INDICATE OPTIONS. 44 JIB DOWN DESCENT ALARM D3044P134BAT BK C6-25 C6 P134BAT RD C6-24 45 GENERATOR OPTION 45 P134TTS RD C6-26 C3 BRN 59 RETRACT BOOM LED 59 BK 134 LOAD WEIGHING LIM. SW. +12V (1) 134 RD WH 134 LOAD WEIGHING LIM. SW. +12V (2) 134 134 LOAD WEIGHING LIM. SW. +12V (3) 134 210 (UNUSED) 210 C4 K LM C46HRN GR CR5#86 C7 BRN C7B-3 C46HRN GR C2B-5 C5 C6-20 P109ANG GR/WH C4B-9 C2 ENGINE C6-34 SNSR BR C4B-4 C6 BRN HARNESS C6-33 C123PBS RD/BK C4B-8 C6-13 C13DE BL/RD C4B-1 C5 BK-CR1 Genie Industries POWER TO PLATFORM OR/BK-41C 12V DC BK-33C 1 TO REMOVE: 1 START RELAY RD-CR19 C7P BRN 2 PUSH GENTLY 2 TACHOMETER RD-24C WH-23C 3 AND LIFT. 3 START INPUT WH-U34-9 4 4 AUX PWR UNIT WH-25D ES0193U 5 U1 5 GROUND 6 6 BATTERY 7 7 TO KEY SW (DIESEL ONLY) 8 8 JUMP TO 7 (GAS ONLY) 9 1 3 4 7 10 9 2 9 IGN OR FUEL ON 10 10 TEMP OR PRESS FAULT 12/24 Volt IGNITON/START MODULE P/N 56057 GROUND BOLT N

December 2013 Section 6 • Schematics Ground Control Box Switch Panel Wiring Diagram, S-60/S-65 S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) NM L KJ I HG F E DCB A TO GROUND 1 CONTROL BOX CONNECTIONS RD TS61-2 WH/RD-CR19#87A WH/RD TS62-6 RD/WH-CR34#87 BR-L46(-) BK/RD-TB9D BK-TB7D RD-TB20D 2 RD/WH-TS61-3 RD-CB2-1 BR-CR34#85 BK/WH-TB8D RD/BK-TB2D BR-HM(-) WH/RD-CR19#87 RD-C134D WH-TS51-2 RD-R14 BR-GND STUD RD TS62-4 RD-L45(+) WH-TB23D RD-TS51-1 BL/BK-TB59D BK-TB22D WH/RD-TB26 RD/WH-CR34#87A RD-TB24D WH-TB21D BK/RD-TB35D RD/WH-R16 RD-TB20C BK/WH-TB34D RD-TB1D RD-C6-33 TS52 WH/RD-R4 1 GR-TB17D BK-TB33D GR/BK-TB18D RD-C32-7 WH/BK-TB5D OR/BK-TB15D WH-TB4D OR-TB14D WH/RD-R2 BL-TB44D GR/WH-TB19D RD-TB27D WH-KS1-1 RD-TS61-2 RD-P4 RD-TB20C RD-P1-2 GR/BK-H6(-) RD-KS1-2 32 NO P4 D3 TS51 63 41 L45 + 33 44 +D64 3 + NO TS61 63 G6 41 WH/RD WH/RD TS56 D4 32 1 21 CB2 R2 R4 4 KS1 31 TS62 64 21 24 64 1 CB1 1 B1 3 TS63 L46 RD/WH B 3 5 R16 R14 NC TS54 TS58 6 2A 1A 3 2 1 D13 3 2B 1B 2 D28 1 NC RD P1 D2 L2 TS59 7 3 2 1 TS57 63 41 21 CB3 CB1 COMPONENT INDEX - GROUND CONTROLS KS1 KEY SWITCH TS57 PLATFORM ROTATE TOGGLE SWITCH 8 CB2 ENGINE CIRCUIT BREAKER, 15A L2 LED - CHECK ENGINE TS58 CB3 CONTROLS CIRCUIT BREAKER, 15A L45 LED - PLATFORM OVERLOAD TS59 JIB BOOM UP / DOWN TOGGLE SWITCH (S-65 OPTION) CB7 CIRCUIT BREAKER, 15A (OPTION) L46 LED - CABLE TENSION TS61 PLATFORM LEVEL UP / DOWN TOGGLE SWITCH CR1 HIGH IDLE CIRCUIT BREAKER P1 EMERGENCY STOP BUTTON TS62 PRIMARY BOOM UP / DOWN TOGGLE SWITCH CR2 START RELAY P4 FUNCTION ENABLE SWITCH TS63 TURNTABLE ROTATE TOGGLE SWITCH CR4 IGNITION / FUEL RELAY R2 RESISTOR, 5W, TURNTABLE ROTATE SPEED U1 PRIMARY BOOM EXTEND / RETRACT TOGGLE SWITCH CR5 HIGH IDLE RELAY R4 RESISTOR, 7.5W, TURNTABLE ROTATE SPEED U33 IGNITION START MODULE CR17 HORN RELAY R14 RESISTOR, 10W, PRIMARY BOOM UPPER ZONE SPEED U34 LOAD SENSE MODULE CR19 HYDRAULIC OIL COOLER RELAY (OPTION) R16 RESISTOR, 7.5W, PRIMARY BOOM UP / DOWN SPEED TIME DELAY RELAY - 2 SECONDS, 10A CR23 TURNTABLE SPEED REDUCTION RELAY TS51 AUXILIARY PUMP TOGGLE SWITCH CR34 DRIVE LIGHTS RELAY (OPTION) TS52 NOTE: DASHED LINES INDICATE OPTIONS. ES0193U G6 PRIMARY BOOM SPEED REDUCTION RELAY TS54 ENGINE START TOGGLE SWITCH H6 TS56 RPM SELECT TOGGLE SWITCH Perkins 404-22 Engine HOUR METER GLOW PLUG TOGGLE SWITCH PLATFORM OVERLOAD ALARM Part No.147753 S-60 • S-65 • S-60 TRAX • S-65 TRAX 6 - 247 S-60 HC • S-60X •S-60XC Downloaded from www.Manualslib.com manuals search engine

December 2013 Section 6 • Schematics Ground Control Box Switch Panel Wiring Diagram S-60/S-65/S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) 6 - 247 6 - 248 Downloaded from www.Manualslib.com manuals search engine

Section 6 • Schematics December 2013 Platform Control Box Wiring Diagram S-60/S-65 S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) 6 - 249 6 - 250 Downloaded from www.Manualslib.com manuals search engine

LM N 2+ U35 CWLITE WH TS49 BK ES0193U 3- 5 BK R20 1 LOAD SENSE RECOVERY OPTION NOTE: DASHED LINES INDICATE OPTIONS. CR76 P26BAT BK CONTROL HARNESS C134PWR RD LS18 TS1 C17OLS WH/RD TO PLATFORM SWITCH PANEL GR/WH GR/WH C19JSV GR/WH TS7 BR BK RD C19JSV GR/WH C4P-7 RD BRN JC3 BR GR/WH + JIB OPT. BRN GND RD OUTPUT RD LS18 CABLE RD-E STOP C134PWR RD BRN - C1 BK P134PWR RD-H1+ CR13-#86 RD TS7 WH BR JK CR27 LIFT / DRIVE RD RD (OPTION) C32BRK WH/RD C1P-6 CR14 C32BRK WH/RD J2-19 CR30 LS18 D23 C40LS OR BR D24 C42LS OR/RD OR WH P23BAT WH C7P-2 I TS14 WH P22BAT BK C7P-1 JIB BR (S-65 OPT.) P26ESTP BK C19JSV GR/WH C4P-7 GH P24FS WH C18PRR GR/BK C4P-6 C2P C7P C9 J3P24FS WH C17PRL GR C4P-5 C3P 12V BATT F.S. 3BRN C15PLD OR/BK C4P-3 C4P 1 C14PLU OR C4P-2 C7P 11 C129JDA BL C3P-10 TS8 BR-GND 1 J8-P109LS GR/WH C3P-12 D88 D89 C59CNK BL/BK C3P-11 L47+ P26BAT BK C9-1 P2 F.S. P25FS RD C9-3 TS2 U13 P24FS WH C9-2 TS4 C1P-12 BK C132PLI1 ALC-500 C4P-10 BK C132PLI2 J8 J2 C45GEN GR/WH C2P-7 December 2013 Platform Control Box Wiring Diagram S-60/S-65 DE F 6 C46HRN GR C2P-5 Part No.147753 S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) 1 C42LS OR/RD C2P-4 C6TRF WH/RD C3P-6 C123PBS RD/BK C4P-8 C7PBE BK C3P-7 C13DE BL/RD C4P-1 C8PBR BK/WH C3P-8 C40LS OR C2P-2 C9PER BK/RD C3P-9 C41RPM OR/BK C2P-3 C30FWD WH C1P-4 C1PBU RD C3P-1 C31REV WH/BK C1P-5 C2PBD RD/BK C3P-2 C36SCC BL C1P-10 C3PBF RD/WH C3P-3 C37SCW BL/BK C1P-11 C5TRR WH/BK C3P-5 C32BRK WH/RD C1P-6 C4TRL WH C3P-4 C29MS RD/WH C1P-3 P109ANG GR/WH C4P-9 SENSOR GND BR C4P-4 C1P Downloaded from www.Manualslib.com manuals search engine C2P C3P C4P C7P 1 BR 2 C4P(BR) J7 C3P(GR) C2P(BK) 1 C1P(GY) P109ANG GR/WH 9 C35RPM BK/RD C1P-9 GR/BK C133PLA C3P-12 S-60 • S-65 • S-60 TRAX • S-65 TRAX C165TRS WH/RD J1 C34SA BK/WH C1P-8 GR/BK-L4 S-60 HC • S-60X • S-60XC SENSOR GND BR C33STR BK C1P-7 C28TTA RD/BK C164PES RD/WH 1 C27AUX RD C1P-1 P134PWR RD C2P-6 P162JPW OR RD-TILT AB C C163PLS WH/BK C28TTA RD/BK C1P-2 GND BR Section 6 • Schematics C160JPL WH/RD C28TTA RD/BK C1P-2 D39 Perkins 404-22 Engine P162JPW OR BATGRN C7P-3 + C159STC BL/WH D40 GND BR H1 C143DEL BL/BK BRN C144DER BL/WH C13DE BL/RD C29MS RD/WH GR/BK-L4 P134PWR RD LS18 CWLITE BK BRN BRN CWLITE WH TS49 6 - 250 2 4 6 8 3 5 7

December 2013 Section 6 • Schematics NM L KJ Platform Control Box Switch Panel Wiring Diagram S-60/S-65 S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) I HG F E DCB A CONTROL HARNESS 1 TO PLATFORM BOX RD LS18TS4TS15 TS6 BL/RD P22BAT C2-1 BK C7P-1 WH C7P-2 BK C9-1 BK J3-3 WH/BK C4P-9 WH/RD J1-4 BL/WH J1-5 OR J1-13 BR J1-14 GR/WH C2P-7 BL/RD J1-16 WH C9P-2 BL/BK J1-6 BL/WH J1-7 RD C9P-3 RD/BK H1 (D40) BK/WH C1P-8 WH CR30#30 C171LS WH/RD BK/RD C1P-9 BK C1P-7 RD C1P-1 RD/WH J1-8 C129JDA BL C3P-10 RD CR14-#86 BR GND STUD GR/BK H1 (D39) BL/BK C3P-11 GR C4P-5 GR/WH C4P-7 WH CR27#87A GR/BK C4P-6 RD/WH J1-2 OR J1-11 BR J1-12 WH/BK J1-3 WH/RD J1-1 OR C4P-2 OR/BK C4P-3 GR C2P-5 ++ 2 JC7 L4 +D12 TS2 1 6 L47 + 1 CR13 JC3 WH TS8 3 TS9 WH WH L1 16 BK 4 TS7 L48 TS48 NC 5 TS1 TS47 NO P3 TS14 BK 2 RD NC BK P22BAT P2 NOTE: DASHED LINES INDICATE OPTIONS. RD 1 ROCKER / STEER OPTION. D27 RD 2 LOAD SENSE RECOVERY OPTION ES0193U 6 COMPONENT INDEX C1 CAPACITOR, JIB CIRCUIT (S-65 OPTION) TS4 RPM SELECT TOGGLE SWITCH 7 CR13 JIB SELECT RELAY (S-65 OPTION) TS6 GLOW PLUG TOGGLE SWITCH CR14 JIB VALVE RELAY (S-65 OPTION) CR27 RELAY - BRAKE CIRCUIT (LIFT / DRIVE OPTION) TS7 PLATFORM ROTATE TOGGLE SWITCH CR30 RELAY - LIMIT SWITCH (LIFT / DRIVE OPTION) TS8 JIB BOOM UP / DOWN TOGGLE SWITCH (S-65 OPTION) CR76 RELAY - LOAD SENSE AUX RECOVERY TS9 PLATFORM LEVEL UP / DOWN TOGGLE SWITCH H1 TILT ALARM TS14 DRIVE SPEED TOGGLE SWITCH JC3 JOYSTICK - DRIVE / STEER TS15 DRIVE ENABLE TOGGLE SWITCH JC7 JOYSTICK - PRIMARY BOOM UP / DOWN, EXTEND / RETRACT, TURNTABLE ROTATE TS47 L1 LED - DRIVE ENABLE TS48 GENERATOR (OPTION) L4 LED - PLATFORM OVERLOAD U13 DRIVE LIGHTS (OPTION) L47 LED - CABLE TENSION U35 ALC500 JOYSTICK CONTROLLER CARD L48 LED - TILT ALARM TIME DELAY RELAY LS18 P2 PLATFORM OVERLOAD LIMIT SWITCH 8 EMERGENCY STOP BUTTON P3 HORN BUTTON R20 RESISTOR - 4700W TS1 AUXILIARY PUMP TOGGLE SWITCH TS2 ENGINE START TOGGLE SWITCH Perkins 404-22 Engine Part No.147753 S-60 • S-65 • S-60 TRAX • S-65 TRAX 6 - 251 S-60 HC • S-60X •S-60XC Downloaded from www.Manualslib.com manuals search engine

December 2013 Section 6 • Schematics Platform Control Box Switch Panel Wiring Diagram S-60/S-65/S60 TRAX/S65 TRAX Perkins Engine Models (AS) (after SN 21629) 6 - 251 6 - 252 Downloaded from www.Manualslib.com manuals search engine

Downloaded from www.Manualslib.com manuals search engine